I will keep you guys updated if it starts leaking again or if i have any other problems with my power steering. With the engine running and the truck in park, check its transmission fluid dipstick and add a half quart at a time until the fluid level appears between the hash marks on the dipstick. The first failure was covered by Chrysler under the three year warranty, but this one is not being covered under the powertrain warranty. Some time later, he got an urgent phone call from Dodge; they couldn't put a mermaid on their burly trucks. Fill powerstering reservouir with recommended fluid and bleed system. The vehicle was destroyed and was not repaired. The contact was advised by the mechanic that the rack and pinion should be replaced.
The vehicle was taken to an independent mechanic who diagnosed that the rack and pinion needed to be replaced. At the time the truck had 62000 kms and 3 months past it's warranty and has not been driven off road. The contact stated that power steering fluid leaked onto the rack and pinion. The first time the rack and pinion went out and this time was during driving the vehicle in four wheel drive in the snow. There were no listed recalls, however, there was a lengthy waiting list. Position drain pan under power steering pump then disconnect the hoses from the pump. Why I give Darrow Dodge another chance is beyond me.
The technician also stated that the rack and pinion and the fuel pump would have to be replaced. This information has been adapted from Chrysler's Tech Service Bulletin, specifically from an article covering many models including the '96 Neon, which is as follows:. The dealer was not notified. Currently the steering is unstable on uneven road surfaces and I do not drive it in the winter. After using one 12 oz bottle the leak on my dodge has stopped! Com for the same failure, and there is another Dodge ram at the dealer right now with the same break down. It terrifies me to think what may happen if this unit was to fail while I was navigating these roads.
The contact noticed that there was also fluid leaking from the vehicle. This is a design flaw, a safety hazard and these trucks need to be recalled before someone is seriously injured or possibly killed. The service manager wasn't as nice, telling me that was the best they could do. They told me the squeak was from the rack and pinion and the boots were also leaking fluid. This may also be caused by a loose or damaged belt, so make sure and check its condition before replacing the pump. Just remove the return line and have an assistant turn the steering wheel back and forth just enough to engage the pump and filling the resevour while doing this. What the dealer was really telling me is that I was a complete doofus for buying this Dodge in the first place and that I should have followed my instincts and bought the Toyota I was thinking of buying.
The approximate failure mileage was 78,000. While the vehicle was taken to an independent mechanic for an unrelated issue, the contact was informed that there was fluid leaking from the axle. Now in 12 month I have replaced the part 4 more times and it is still broken leaving me everytime with a total loss of steering. Darrow Dodge replaced rack under warranty. The failure mileage was 54,300. Shame on Dodge Chrysler products for making such a garbage truck. Please take action to force Dodge to correct this design flaw before someone dies.
Caused loss of control on highway. With an 18mm wrench remove the top front line from rack and pinion I could reach it from the top. New power steering hoses have high-quality crimps and fittings that prevent leaks. Next time it could cause a fatal car accident. A small power steering fluid leak can make your Ram 2500 difficult to turn. You will need a 10 socket and an extension to slide in under the reservoir to find the nut that holds the bottom fast.
The contact stated that the first week of February 2007 he observed under the vehicle a fluid leak present on both seals of the rack and pinion steering. You will need to start by disconnecting the return hose smaller dia and allowing the reservoi … r to drain into a bottle, etc. I just cannot figure out why they haven't recalled it with so many complaints. The rack and pinion only leaks when it gets cold outside so i figured before doing any big repair i would try a bottle of Lucas power steering stop leak. Suspect a cracked hose or reservoir but since this truck was bought in rough shape body wise to use as a hauling and towing truck salvage title and engine was in great condition with only 63K on the clock. These vehicles should not be made available to drive if there this dangerous.
Then start it up and see if you can see and leaks, move the steering wheel through a couple of turns and watch for leaks. . Steering constantly wanting to sway back and forth when in motion makes truck bounce back and forth from lane lines, had bearings,hub,struts,lower control arms,and rack and pinion replaced still no better if not worse, found that others are having this issue also believe that steering gear box that was installed when truck came from manufacturer is faulty and this is definitely a safety concern. The thought of a clear safety on the truck and just over 1000km put on it and the rack and pinion needing to be replaced is not looking good for the dealership. When you check your power steering fluid level, make sure your Ram 2500 is parked on a level surface with the 5.